PVP1600K9R212美國派克PVP泵*

價格僅供參考，實際價格歡迎詢價！
液壓元件（閥門、泵、油缸等），歡迎詢價訂貨！

力士樂電磁閥，泵，油缸，閥全系列。ASCO電磁閥，ATOS液壓，SMC電磁閥，派克電磁閥。液壓閥、液壓泵、油缸、壓力繼電器、放大器等歡迎詢價訂貨。

柱塞泵使用維護規范
啟泵前檢查與調試 

泵運轉前應進行全面堅檢查，發現問題及時整改，檢查各零部件配套件是否齊全完好。 檢查各連接密封部位是否符合要求。 
設備投產前，管線應試壓保證其承受壓力為實際壓1.2倍，保證不滲不漏，對摻稀流程進行清焊渣。新泵投產前應清除曲軸箱內積水、污物，檢查電動機檢查連桿瓦螺栓.鎖片.連接卡子等部調整各油封。向曲軸箱內注入柴油面至油標的2/3~3/4之間（正常使用同時運轉2臺以上柱塞泵，對緩沖器沖氨氣，達到盤動皮帶輪，使泵轉動3~5圈，檢查泵有無卡阻現檢查整個電器系統，各部位電器元件.接點.儀表是否齊全.靈敏。供電電壓是否超限，額定電壓為低電壓應為361V，高電壓應為418V)；電2MΩ. 

機泵的啟動操作規程
在對機泵進行檢查、盤車無問題后，打開管路上的進打開管路上的回流針閥。 打開泵出口截止閥及壓力表各閥門。 點動電動機，檢查電動機的旋轉方向是否與曲軸箱啟動電動機，空載運行10min~20min,監視各部運轉.響聲.潤滑.泄露情況。各部正常后，1.0MPa，先后打開管路上摻稀閥門及采油數井每隔15分鐘計量注入量，及時調整回流針閥直到達新泵和大修理泵啟動后，應經過2h以上的空載運行20min升壓5MPa，升至工30min以上。 

停泵操作程序 
正常停泵 .出口閥門。 使排出壓力表逐漸回到“零”位。 自動停泵，緊急停泵 .巨大聲響.冒煙。倒泵操作 

維護保養 
柱塞泵要建立設備運轉記錄本，每次檢查.維修均要妥善保管在設備所在井站值班室。 新泵或大修出廠的泵，運行120小時后更換(與設備生產廠家要求的潤滑油型號一致或)，運行360小時再次更換，以后每2000小時更換一次齒輪油。 每運轉160-170小時，由生產班長帶領井站職工進行檢查。

日常維護內容 
 
.異響等。 
.曲軸箱的溫度情況。 
.打滑等現象。 
.接線.顯示是否齊全.完好。 

 一級維護保養內容 
檢查曲軸.軸承.連桿及所有螺絲.螺母等并予以檢查連接桿的磨損情況。 根據潤滑油實際漏失情況，決定是否更換油封。 對油品進行質量檢測，根據檢測結果決定是否更換。檢查柱塞連接是否緊固。 檢查柱塞磨損及盤根密封情況。 檢查液力端螺絲松動情況并進行緊固。 清洗.檢查吸入端的過濾器。 檢查變頻器是否齊全.完好，有無受潮.過熱現。檢查電動機有無受潮及淋水現象，固定是否牢固。
 
二級維護保養內容 
進行設備的維護保養。 檢查曲軸與軸瓦的配合間隙，并予以調整或更檢查十字頭.十字頭銷.獅子頭導軌.軸承的磨損，檢查連桿有無變形情況。 檢查大皮帶輪與曲軸的鏈接請況，并檢查曲軸動力端整體密封.傳動良好，達到不滲.不漏.強制潤滑的設備，還應檢查油泵的磨損情況，在檢查柱塞連接.柱塞磨損及盤根密封.進出口檢查盤根盒（含盤根盒壓帽），對盤根盒壓帽及盤根盒固定螺栓及螺母進行除銹.防腐處檢查電動機的軸承磨損情況，補充或更換。 清理電風扇及風扇罩等灰塵。 對電動機的絕緣電阻進行測試，電動機接地電2MΩ。 

  PVP1600K9R212
PVP16102L12
PVP16102L212
PVP16102L26A1C12
PVP16102L26A212
PVP16102L2P12
PVP16102L2VO12
PVP16102L6A1C12
PVP16102R12
PVP16102R212
PVP16102R26A112
PVP16102R26A212
PVP16102R26A212-
PVP16102R26A2A12
PVP16102R26A2M12
PVP16102R26A2V12
PVP16102R26A412
PVP16102R26A4V12
PVP16102R26T12
PVP16102R2H12
PVP16102R2M12
PVP16102R6A112-
PVP16102R6A212
PVP16102R6A2ME12
PVP16102RME12
PVP16104L12
PVP16104L212
PVP16104L26A1C12
PVP16104L26A212
PVP16104L2M12
PVP16104L6A212-
PVP16104R12
PVP16104R212
PVP16104R26A112
PVP16104R26A1M12
PVP16104R26A1ME12
PVP16104R26A212
PVP16104R26A2P12
PVP16104R26A412
PVP16104R26T12
PVP16104R2A12
PVP16104R2M12
PVP16104R2MV12
PVP16104R2P12
PVP16104R2V12
PVP16104R2VM12
PVP16104R6A112
PVP16104R6A1V12-
PVP16104R6A212
PVP16104R6A412
PVP16104RM12
PVP16105R12
PVP16105R212
PVP16106L212
PVP16107L212
PVP16107L2VO12
PVP16109R212
PVP1610B2L212
PVP1610B2R12
PVP1610B2R212
PVP1610B2R26A2P12-
PVP1610B2R2MP12
PVP1610B2RVP12
PVP1610B4L12
PVP1610B4L212
PVP1610B4L26A412
PVP1610B4LH12
PVP1610B4R12
PVP1610B4R212
PVP1610B4R26A112
PVP1610B4R26A212
PVP1610B4R26A2VM12
PVP1610B4R26A412
PVP1610B4R26T12
PVP1610B4R2M12
PVP1610B4R6A1A12
PVP1610B4R6A4M12
PVP1610B4R6A4MP12
PVP1610B5L212
PVP1610B5R212
PVP1610B6L12
PVP1610B6L212
PVP1610B6L2M12
PVP1610B7L212
PVP1610B8R12
PVP1610B9R212
PVP1610B9R2H12
PVP1610BL12
PVP1610BL212
PVP1610BR12
PVP1610BR212
PVP1610BR2A12
PVP1610BR2M12
PVP1610BR2P12
PVP1610BRAP12
PVP1610BRM12
PVP1610BRP12
PVP1610C2R26A2P12-
PVP1610C2R2P12
PVP1610CLAP12
PVP1610CRAP12
PVP1610K8R2VM12
PVP1610K9R12
PVP1610K9R212
PVP1610L12
PVP1610L212
PVP1610LM12
PVP1610R12
PVP1610R212
PVP1610R2A12
PVP1610R2H12
PVP1610R2M12
PVP1610R2ME12
PVP1610R2MP12
PVP1610R2MV12
PVP1610R2P12
PVP1610R2V12
PVP1610R2VM12
PVP1610RA12
PVP1610RM12
PVP1610RME12
PVP1610RP12
PVP1610RV12
PVP16202L212
PVP16202L26A212
PVP16202L2P12
PVP16202L6A212
PVP16202LV12
PVP16202R12
PVP16202R212
PVP16202R26A112
PVP16202R26A1M12
PVP16202R26A212
PVP16202R26A2A12
PVP16202R26A412
PVP16202R26A4AV12
PVP16202R2H12
PVP16202R2M12
PVP16202R2P12
PVP16202R2V12
PVP16202R6A112
PVP16202R6A412
PVP16202RH12
PVP16202RM12
PVP16204L12
PVP16204L212
PVP16204L26A112
PVP16204L26A1A12
PVP16204L26A2M12-
PVP16204L26A2P12-
PVP16204L26TP12
PVP16204L2M12
PVP16204L6A112
PVP16204L6A212
PVP16204L6A2M12
PVP16204L6TM12
PVP16204LM12
PVP16204R12
PVP16204R212
PVP16204R26A112
PVP16204R26A1M12
PVP16204R26A1MP12
PVP16204R26A1V12
PVP16204R26A212
PVP16204R26A2ME12-
PVP16204R26A2MP12
PVP16204R26A2MV12
PVP16204R26A2V12
PVP16204R26A2VM12-
PVP16204R26A412
PVP16204R26A412-
PVP16204R26A4M12
PVP16204R26A4P12
PVP16204R2M12
PVP16204R2P12
PVP16204R2V12
PVP16204R2VM12
PVP16204R6A112
PVP16204R6A212
PVP16204R6A2A12
PVP16204R6A2M12
PVP16204R6A2MV12
PVP16204R6A2V12
PVP16204R6A412
PVP16204R6A4M12
PVP16204R6A4MV12
PVP16204RM12
PVP16204RMP12
PVP16204RP12
PVP16204RV12
PVP16204RVM12
PVP16205L12
PVP16205L212
PVP16205R12
PVP16205R212
PVP16205R2P12
PVP16205R2V12
PVP16205RM12
PVP16208R2M12
PVP16208RA12
PVP16209RM12
PVP1620B2L212
PVP1620B2R12
PVP1620B2R212
PVP1620B2R6A412
PVP1620B2RP12
PVP1620B4L212
PVP1620B4L2M12
PVP1620B4L6A412
PVP1620B4R12
PVP1620B4R212
PVP1620B4R26A112
PVP1620B4R26A4M12-
PVP1620B4R2M12
PVP1620B4R6A412
PVP1620B4RA12
PVP1620B4RAP12
PVP1620B4RM12
PVP1620B4RMP12
PVP1620B4RP12
PVP1620B5R12
PVP1620B7L212
PVP1620B8RVM12
PVP1620BL212
PVP1620BL2A12
PVP1620BLA12
PVP1620BLP12
PVP1620BR12
PVP1620BR212
PVP1620BR2A12
PVP1620BR2M12
PVP1620BR2P12
PVP1620BRA12
PVP1620BRAP12
PVP1620BRM12
PVP1620C2R212
PVP1620C2R6A412
PVP1620C2R6A4P12
PVP1620C4L26A412
PVP1620C4L26A4P12
PVP1620C4R12
PVP1620C4R6A412
PVP1620C9R12
PVP1620CR212
PVP1620CR2P12
PVP1620CRA12
PVP1620K8R12
PVP1620K8R2M12
PVP1620K8R9A4VM12
PVP1620K9R212
PVP1620K9R2P12
PVP1620K9R9A2P12
PVP1620K9R9A4P12
PVP1620K9RV12
PVP1620L12
PVP1620L212
PVP1620L2A12
PVP1620L2MV12
PVP1620L2P12
PVP1620LA12
PVP1620LM12
PVP1620LP12
PVP1620LV12
PVP1620R12
PVP1620R212
PVP1620R2A12
PVP1620R2AP12
PVP1620R2H12
PVP1620R2M12
PVP1620R2ME12
PVP1620R2MVP12
PVP1620R2P12
PVP1620R2V12
PVP1620R2VM12
PVP1620R2VO12
PVP1620R2VP12
PVP1620RA12
PVP1620RC12
PVP1620RH12
PVP1620RM12
PVP1620RMP12
PVP1620RP12
PVP1620RV12
PVP16302L12
PVP16302L212
PVP16302L26A112
PVP16302L26A1VM12
PVP16302L26A212
PVP16302L26A412
PVP16302L26T12
PVP16302L2M12
PVP16302L6A212
PVP16302R12
PVP16302R212
PVP16302R26A112
PVP16302R26A1M12
PVP16302R26A1ME12
PVP16302R26A1VM12
PVP16302R26A212
PVP16302R26A2A12
PVP16302R26A2M12
PVP16302R26A2MVP12
PVP16302R26A2P12
PVP16302R26A2V12
PVP16302R26A412
PVP16302R26A4M12
PVP16302R26A4VM12
PVP16302R26T12
PVP16302R26TMP12
PVP16302R2M12
PVP16302R2ME12
PVP16302R2MP12
PVP16302R2P12
PVP16302R2V12
PVP16302R6A112
PVP16302R6A1C12
PVP16302R6A1M12
PVP16302R6A1MV12
PVP16302R6A1V12
PVP16302R6A212
PVP16302R6A2A12
PVP16302R6A2M12
PVP16302R6A2V12
PVP16302R6A412
PVP16302R6A4M12
PVP16302R6T12
PVP16302RA12
PVP16302RH12
PVP16302RM12
PVP16302RMP12
PVP16302RP12
PVP16302RV12
PVP16302RVO12
PVP16304L12
PVP16304L212
PVP16304L26A1H12
PVP16304L26A1VM12
PVP16304L26A212
PVP16304L26A2M12
PVP16304L26A2VM12
PVP16304L2H12
PVP16304L2M12
PVP16304L6A212